Rover Connection-Recall Info

Discovery Series I
Door Latch
Driveshaft to Differential Connection

Discovery Series II

Range Rover Classic
Fuel Tank
Driveshaft to Differential Connection

Range Rover 4.0/4.6
Rear Axle Trailing Arms
ABS High Pressure Hose
Engine Drive Belt Idler Pulley

Defender
Batter-Warning Label
Driveshaft to Differential Connection

Discovery Series I

Door Latch

A possible defect which relates to motor vehicle safety may exist in some 1995 and 1996 model year Land Rover "Discovery" vehicles imported by Land Rover North America, Inc.

DESCRIPTION OF DEFECT
The right front door on some 1995 and 1996 Discovery vehicles may fail to latch fully, causing the door to 'bounce" back off of the door seals. Procedures have been established to inspect all side doors on all affected vehicles and to rectify latch problems determined by that inspection. An extended length latch mounting fastener has been introduced to assure proper orientation of the right front door latch relative to the mounting leg of the adjacent window frame. The new fastener must be installed on vehicles within the following VIN ranges: SA156138 - TA200000, SA500045 - TA534099, TA700000 - TA703236 In cases where latch loads have been excessive, replacement of the latch may be required.

VEHICLES INVOLVED/CUSTOMER NOTIFICATION
A total of 20141 Discovery vehicles are involved in this recall action.

CUSTOMER NOTIFICATION LETTER
January 24, 1997

Dear Land Rover Owner

This notice is sent to you in accordance with the requirements of the National Traffic and Motor Vehicle Safety Act. Rover Group, Ltd., manufacturer of Land Rover vehicles, has determined that a defect which relates to motor vehicle safety exists in some 1995 and 1996 Land Rover Discovery vehicles within a specific build range. The defect may or may not be present in all vehicles, however, the suspect components will be checked and, if found to be defective, repaired or replaced free of charge on all affected vehicjes within the specified build range.

On some vehicles, a side door may fail to latch fully when being closed, causing the door to "bounce' back off the door seals. In rare circumstances, this condition could lead to inadvertent opening of the affected side door which would place an occupant seated next to the door at risk of harm.

To minimize the risk of inadvertent door opening prior to the Recall Inspection, please close all dadr firmly and verify that each door is corectly latched by applying pressure from within. Once assured that the latch is engaged, lock the door by pushing down on the door sill button. As always, take advantage of an additional safety margin for you and your passengers by Insisting 46 everyone wear their seat belts.

We will inspect the integrity of all door latching systems and perform repairs, if necessary, to correct any defects found. The parts necessary to complete this action are currently available at your Land Rover Retailer. The time required to perform this Recall, depending on the extent of work necessary, could vary between 30 minutes and 6 hours. The personnel at your dealer are fully prepared to serve you.

Please contact your Land Rover Retailer to arrange for the work to be performed as soon as possible. Your dealer is prepared to make every effort to perform the modification at a convenient time which fits your schedule. If you experience any difficulty in making these arrangements, please contact one of our Owner Care Representatives at 1-800-637-6837.

PLEASE NOTE: If the vehicle to which this notice applies has been leased and you are the lessor, Vo MUST send a copy of this notice to the lessee.

If your dealer does not repair your vehicle without charge and within 60 days, you may submit a complaint to the Administrator, National Highway Traffic Safety Administration, Washington, D.C., 20590, or call the toll-free Auto Safety Hotline at 1-800-424-9393. (Washington, D.C. area residents may call (202) 366-0123). You may also call our Owner Care Department or write to:

Land Rover North America, Inc.
P.O. Box 1503
4371 Parliament Place
Lanham, MD 20706
Attn: Owner Care Department

We apologize for any inconvenience caused by this Recall, but trust that you understand the need to have this condition rectified. Land Rover North America Dan Miller Manager, Warranty

Driveshaft to Differential Connection

A possible defect which relates to motor vehicle safety may exist in some 1995 model year Land Rover vehicles imported by Land Rover North America, Inc.

DESCRIPTION OF DEFECT
A limited number of vehicles may have incorrect nuts fitted to the bolts which attach the driveshaft to the differential pinion flange. This condition could possibly cause one or both of the driveshafts to become disconnected from the differential, which could result in loss of control of the vehicle.

VEHICLES INVOLVED/CUSTOMER NOTIFICATION
A total of 155 U.S. and Canadian Range Rover Classic, Discovery and Defender 90 vehicles are involved in this recall action.

CUSTOMER NOTIFICATION LETTER
June 2,1995

Dear Land Rover Owner:

This notice is sent to you in accordance with the requirements of the National Traffic and Motor Vehicle Safety Act.

Rover Group, Ltd., manufacturer of Land Rover vehicles, has determined that a defect which relates to motor vehicle safety exists in some 1995 Land Rover vehicles within a specific build range. The defect may or may not exist in all vehicles, however, the parts will be replaced on all vehicles within the specified build range.

Improper hardware may have been used to fit one or both of the driveshafts to the differentials in a Defender 90 or the front driveshaft only in a Discovery or Range Rover Classic. The failure of the hardware could cause one or both of the driveshafts to become dislodged from the differentials, possibly resulting in loss of control of the vehicle.

In order to remedy such a defect, your Land Rover Dealer will replace all of the nuts and bolts holding the driveshafts to the differentials. This action is being taken voluntarily and all Land Rover Dealers have been supplied with repair instructions. The work will be performed at no charge to you.

The parts necessary to complete this action are currently available for your Dealer to order from Land Rover North America. The time required to perform this work is approximately 30 minutes.

Please contact your Land Rover Dealer to arrange for this recall to be effected as soon as possible. If you experience any difficulty in arranging to have this work performed, please contact our Owner Care Department at 1 -800 -637 -683 7.

If your Dealer does not repair your vehicle without charge and within 60 days, you may submit a complaint to the Administrator, National Highway Traffic Safety Administration, Washington, D.C, 20590,or call toll-free AutosafetyHotlineatl-800-424-9393. (Washington D.C area residents may call (202) 366-0123). You may also call our Owner Care Department or write to: Land Rover North America, Inc. 4390 Parliament Place Lanham, MD 20706 Attn: Owner Care Department

Please note, under Federal law, if the vehicle to which this notice applies has been leased and you are the lessor..you must send a cop,y of this notice to the lessee. We sincerely regret any inconvenience this recall may cause. Land Rover North America, Inc.

Discovery Series II

Range Rover Classic

Fuel Tank

A defect which relates to motor vehicle safety exists in 1987 through 1990 and some 1991 model year Range Rover vehicles imported by Land Rover North America, Inc.

DESCRIPTION OF DEFECT
Land Rover has identified a defect in the fuel tank fitted to a number of 1987 through 1991 Range Rover vehicles. The Defect could lead to corrosion at the bottom of the fuel tank in the area above the stone guard. If the corrosion were to perforate the fuel tank wall, fuel would seep into the space between the tank and stone guard producing fuel odors. If the odor were unnoticed or ignored, fuel leakage could eventually result and present a fire hazard in the presence of an ignition source. Reported failures are primarily from areas where road salt is used during the winter. However, all affected vehicles will have the fuel tank inspected/ replaced.

VEHICLES INVOLVED/CUSTOMER NOTIFICATION
U.S. and Canadian 1987 through 1991 Range Rover vehicles within the VIN ranges shown below are involved in this recall action: Model Year Model VIN Range 1987 All HA265406-HA301324 1988 All JA300620-JA344935 1989 All KA336636-KA395665 1990 All LA391190-LA457333 1991 SXGD MA442792-MA462136

CUSTOMER NOTIFICATION LETTER
November 30, 1995

Dear Range Rover Owner:

This notice is sent to you in accordance with the requirements of the National Traffic and Motor Vehicle Safety Act.

Rover Group, Ltd., manufacturer of Land Rover vehicles, has determined that a defect which relates to motor vehicle safety exists in some 1987 through 1991 Range Rover vehicles within a specific build range. The defect may or may not be apparent in all vehicles, however, the part will be replaced on all affected vehicles within the specified build range.

The Defect could lead to corrosion at the bottom of the fuel tank in the area above the stone guard. If the corrosion were to perforate the fuel tank wall, fuel would seep into the space between the tank and stone guard producing fuel odors. If the odor were unnoticed or ignored, fuel leakage could eventually result and present a fire hazard in the presence of an ignition source.

Reported failures are primarily from areas where road salt is used during the winter. However, regardless of where you live or drive, the fuel tank will be replaced at no charge to you. This action is being taken voluntarily and the necessary work can be performed by any authorized Land Rover retail dealer.

The parts necessary to complete this action are currently available at your Dealer and the time required to perform this work is approximately 2 hours.

If you have already had the fuel tank in your Range Rover replaced, it is possible that the tank may not have to be replaced again. Your Dealer will be able to confirm the kind of fuel tank that is currently in your vehicle and whether or not it will have to be replaced. If you paid for all or part of having a fuel tank replaced, kindly provide your dealer with a copy of your receipt for having the work performed and you will be reimbursed.

Please contact your Land Rover Dealer to arrange for this work to be performed as soon as possible. Your dealer is prepared to make the modification as convenient as possible for you at a time that fits your busy schedule. If you experience any difficulty in making these arrangements, please contact one of our Owner Care Representatives at 1-800-637-6837.

If your Dealer does not repair your vehicle without charge and within 60 days, you may submit a complaint to the Administrator, National Highway Traffic Safety Administration, Washington, D.C., 20590, or call the toll-free Auto Safety Hotline at 1-800-424-9393. (Washington, D.C. area residents may call ((202) 366-0123). You may also call our Owner Care Department or write to:

Land Rover North America, Inc.
4390 Parliament Place
Lanham, MD 20706
Attn: Owner Care Department

Please note, if the vehicle to which this notice applies has been leased and you are the lessor, you should send a codv of this notice to the lessee. We apologize for any inconvenience caused by this recall, but trust that you understand the need to have this condition rectified. Land Rover North America Barbara R. Wheatley Manager, Owner Care

Driveshaft to Differential Connection

A possible defect which relates to motor vehicle safety may exist in some 1995 model year Land Rover vehicles imported by Land Rover North America, Inc.

VEHICLES INVOLVED/CUSTOMER NOTIFICATION
A total of 155 U.S. and Canadian Range Rover Classic, Discovery and Defender 90 vehicles are involved in this recall action.

CUSTOMER NOTIFICATION LETTER
June 2,1995

Dear Land Rover Owner:

This notice is sent to you in accordance with the requirements of the National Traffic and Motor Vehicle Safety Act.

The parts necessary to complete this action are currently available for your Dealer to order from Land Rover North America. The time required to perform this work is approximately 30 minutes.

Range Rover 4.0 SE

Rear Axle Trailing Arms

A defect which relates to motor vehicle safety may exist in some 1995 model year Range Rover 4.0 SE vehicles imported by Land Rover North America, Inc.

DESCRIPTION OF DEFECT
Land Rover has identified a potential defect in the rear axle trailing arms fitted to a number of Range Rover 4.0 SE vehicles caused by fracturing of the aluminum eye which attaches the arm to the chassis frame. Should one of these arms fail, the driver may notice an audible "knocking" noise prior to separation of the arm from the chassis. If the noise @ ignored, there is a risk that the arm will separate resulting in vehicle instability and possible loss of control.

VEHICLES INVOLVED/CUSTOMER NOTIFICATION
U.S. and Canadian Range Rover 4.0 SE vehicles within the VIN range SA300190 SA309757 are involved in this recall action.

CUSTOMER NOTIFICATION LETTER
March 22, 1996

Dear Range Rover 4.0 SE Owner:

This notice is sent to you in accordance with the requirements of the National Traffic and Motor Vehicle Safety Act.

Rover Group, Ltd., manufacturer of Land Rover vehicles, has determined that a defect which relates to motor vehicle safety exists in certain 1995 Range Rover 4.0 SE vehicles. This recall campaign relates to potentially defective rear suspension trailing arms. The rear suspension trailing arms, which connect the rear axle to the chassis, may fail by cracking and fracture of the aluminum ends and separate from the chassis. If you hear any knocking noise emanating from the rear of the vehicle, pull over at once. If this noise is ignored and the vehicle continues to be driven, there is risk that the arm will separate resulting in vehicle instability and possible loss of control, which could cause a crash. Do not drive your Ran-ge Rover if you know, or suspect, that one of the trailin-q arms has failed or is about to fail.

If you should hear a "knocking" noise in the rear suspension, stop the vehicle immediately and call Land Rover Road Recovery at 1-800-444-3700 and one of our representatives will make the necessary arrangements to have your vehicle transported to the nearest Land Rover Dealer.

Even though, to date, we know of no rear suspension trailing arm failures in the United States or Canada, in order to ensure that your Range Rover 4.0 SE does not contain potentially defective arms, we will be replacing the suspect parts at no charge to you. This action is being taken voluntarily and the necessary work can be performed by any authorized Land Rover Dealer.

The parts necessary to complete this action are currently available at your Dealer and the time required to perform this work is approximately 1 1/2hours.

Please contact your Land Rover Dealer to arrange for this work to be performed as soon as possible. Your dealer is prepared to make the modification as convenient as possible for you at a time that fits your busy schedule. If you experience any difficulty in making these arrangements directly with your dealer, please contact one of our Owner Care Representatives at 1-800-637-6837.

If your Dealer does not repair your vehicle without charge and within a reasonable time, you may submit a complaint to the Administrator, National Highway Traffic Safety Administration, Washington, D.C., 20590, or call the toll-free Auto Safety Hotline at 1-800-424-9393. (Washington, D.C. area residents may call (202) 366-0123). You may also call our Owner Care Department or write to:

Land Rover North America, Inc.
4390 Parliament Place
Lanham, MD 20706
Attn: Owner Care Department
(800) 637-6837

Please note, if the vehicle to which this notice applies has been leased and you are the lessor, you should send a copy of this notice to the lessee.

We sincerely regret any inconvenience this recall may cause you. However, we believe that this is a necessary measure which should be completed as soon as possible. Land Rover North America Barbara R. Wheatley Manager, Owner Care

ABS High Pressure Hose

A possible defect which relates to motor vehicle safety may exist in some 1995 model year Range Rover 4.0 SE vehicles imported by Land Rover North America, Inc.

DESCRIPTION OF DEFECT
Land Rover has identified a possible defect in the ABS high pressure hose fitted to a number of Range Rover 4.0 SE vehicles. Should this brake hose fail, the driver would notice the illumination of the amber ABS, the red brake, and amber traction control warning lights, followed by a reduction in braking capability. However, since there are two separate hydraulic circuits in the braking system, if the hose was to fail, the secondary braking system would remain functional, enabling the driver to stop the vehicle with increased pedal effort

VEHICLES INVOLVED/CUSTOMER NOTIFICATION
U.S. and Canadian Range Rover 4.0 SE vehicles within the VIN range SA300190 SA313142 are involved in this recall action.

CUSTOMER NOTIFICATION LETTER
July 3, 1995

Dear Range Rover 4.0 SE Owner:

This notice is sent to you in accordance with the requirements of the National Traffic and Motor Vehicle Safety Act.

Rover Group, Ltd., manufacturer of Land Rover vehicles, has determined that a defect which relates to motor vehicle safety may exist in some 1995 Range Rover 4.0 SE vehicles within a specific build range. The defect may or may not exist in all vehicles, however, the part will be replaced on all vehicles within the specified build range.

This recall campaign relates to a potentially defective ABS brake hose. Should this brake hose fail, you would notice the illumination of the amber ABS, the red brake, and amber traction control warning lights, followed by a reduction in braking capability. However, since there are two separate hydraulic circuits in the braking system, if the hose fails, the brakes will continue to operate but with noticeably greater pedal effort required. Should this occur, stop the vehicle and call Land Rover Road Recovery at 1-800-444-3700 and one of our representatives will make the necessary arrangements to have your vehicle transported to the nearest Land Rover Dealer.

In order to ensure that the ABS braking system in your Range Rover 4.0 SE does not contain a potentially defective hose, we will be replacing the suspect brake hose at no charge to you. This action is being taken voluntarily and the necessary work can be performed by any authorized Land Rover Dealer.

Please contact your Land Rover Dealer to arrange for this work to be performed as soon as possible. Your dealer is prepared to make the modification as convenient as possible for you at a time that fits your busy schedule. Pick up and delivery services are available in many areas. If you experience any difficulty in making these arrangements, please contact one of our Owner Care Representatives at 1-800-637-6837.

If your Dealer does not repair your vehicle without charge and within 60 days, you may submit a complaint to the Administrator, National Highway Traffic Safety Administration, Washington, D.C., 20590, or call the toll-free Auto Safety Hotline at 1-800-424-9393. (Washington, D.C. area residents may call ((202) 366-0123). You may also call our Owner Care Department or write to:

Land Rover North America, Inc.
4390 Parliament Place
Lanham, MD 20706
Attn: Owner Care Department

Please note, under Federal Law, if the vehicle to which this notice apg)iies has been leased and you are the lessor, you must send a copy of this notice to the lessee, We sincerely regret any inconvenience this recall may cause you and your family, however, we trust that you understand the necessity to have this work performed. Land Rover North America Barbara R. Wheatley Manager, Owner Care

Engine Drive Belt Idler Pulley

A defect which relates to motor vehicle safety exists in some 1995 model year Range Rover 4.0 SE vehicles imported by Land Rover North America, Inc.

DESCRIPTION OF DEFECT
Land Rover has identified a defect in the engine drive belt idler pulley fitted to a number of Range Rover 4.0 SE vehicles. Should this idler pulley fail, the driver would notice a loud mechanical noise from the engine compartment accompanied by the illumination of the red battery symbol in the instrument pack and the message "ALTERNATOR FAULT" 'in the message center. In addition, there will be no power assisted steering.

VEHICLES INVOLVED/CUSTOMER NOTIFICATION
U.S. and Canadian Range Rover 4.0 SE vehicles within the VIN range SA300190 SA319682 are involved in this recall action.

CUSTOMER NOTIFICATION LETTER
October 3, 1995

Dear Range Rover 4.0 SE Owner:

This notice is sent to you in accordance with the requirements of the National Traffic and Motor Vehicle Safety Act.

Rover Group, Ltd., manufacturer of Land Rover vehicles, has determined that a defect which relates to motor vehicle safety exists in some 1995 Range Rover 4.0 SE vehicles within a specific build range. The defect may or may not exist in all vehicles, however, the part will be replaced on all vehicles within the specified build range.

This recall campaign relates to a potentially defective engine drive belt idler pulley. In order to avoid possible injury from pieces of a failed idler pulley, do not, under any circumstances, open the hood with the engine running until the required work has been completed. Should the idler pulley fail, the driver would notice a loud mechanical noise from the engine compartment accompanied by the illumination of the red battery symbol in the instrument pack and the message "ALTERNATOR FAULT" in the message center. In addition, there will be no power assisted steering. In the event of a failure, stop the vehicle and call Land Rover Road Recovery at 1-800-444-3700 and one of our representatives will make the necessary arrangements to have your vehicle transported to the nearest Land Rover Dealer.

In order to ensure that your Range Rover 4.0 SE does not contain a potentially defective idler pulley, we will be replacing the suspect pulley at no charge to you. This action is being taken voluntarily and the necessary work can be performed by any authorized Land Rover Dealer.

The parts necessary to complete this action are currently available at your Dealer and the time required to perform this work is approximately 30 minutes. The people at your dealer are fully prepared to serve you. Please contact your Land Rover Dealer to arrange for this work to be performed as soon as possible. Your dealer is prepared to make the modification as convenient as possible for you at a time that fits your busy schedule. Your dealer can perform the repair at your home or business. If you experience any difficulty in making these arrangements, please contact one of our Owner Care Representatives at 1-800-637-6837.

If your Dealer does not repair your vehicle without charge and within 60 days, you may submit a complaint to the Administrator, National Highway Traffic Safety Administration, Washington, D.C., 20590, or call the toll-free Auto Safety Hotline at 1-800-424-9393. (Washington, D.C. area residents may call ((202) 366-0123). You may also call our Owner Care Department or write to:

Land Rover North America, Inc.
4390 Parliament Place
Lanham, MD 20706
Attn: Owner Care Department

Please note, if the vehicle to which this notice applies has been leased and you are the lessor, you should send a copy of this notice to the lessee. We realize that for many of you this is the second recall notification that you have received regarding your Range Rover 4.0 SE and we sincerely regret any inconvenience this recall may cause you. However, we believe that by taking a proactive stance, we will be able to provide a level of reliability that your vehicle might not otherwise have. Land Rover North America Barbara R. Wheatley Manager,. Owner Care

Defender

Battery-Warning Label

An issue regarding non-compliance with a labeling regulation exists in 1993 through 1995 model year Land Rover Defender vehicles imported by Land Rover North America, Inc.

DESCRIPTION OF DEFECT
Land Rover has identified a number of vehicles that were built without the proper warning label affixed to the battery. This label contains important information concerning the inherent dangers related to the acid contained within the battery and the care that must be taken when working on or around batteries.

VEHICLES INVOLVED/CUSTOMER NOTIFICATION
U.S. and Canadian 1993 through 1995 Land Rover Defender vehicles within VIN range PA919935 through SA981838 are involved in this recall action.

CUSTOMER NOTIFICATION LETTER
August 2, 1996

Dear Land Rover Defender Owner:

This notice is sent to you in accordance with the requirements of the National Traffic and Motor Vehicle Safety Act.

Rover Group, Ltd., manufacturer of Land Rover vehicles, has determined that a non-compliance with the Consumer Product Safety Commission Battery Warning Label regulation, 16 CFR part 1500 exists for your vehicle. The battery warning label was omitted from all wet cell batteries supplied in 1993 through 1995 Land Rover Defender vehicles. The Consumer Product Safety Commission regulation requires that all motor vehicle batteries contain a label alerting people to the dangerous nature of lead/acid wet cell batteries with respect to explosion, acid bum, and poisoning hazards.

With respect to battery handling and safety, please be aware that batteries contain sulfuric acid which, if directly contacted, can cause blindness, severe bums or other injury. Eye protection should be worn when working in close proximity to batteries. To prevent explosion, smoking, flames and sparks should be avoided in the presence of batteries. Batteries should always be kept out of reach of children. Batteries should not be tipped and vent caps should be kept tight.

For your convenience, we have enclosed the label to be affixed to your battery along with the relevant sections of the owner's handbook which refer to battery handling and safety. Please follow the attached instructions regarding installation. If you do not wish to install the label yourself, you may take the vehic4e and label to your Dealer who will be happy to install it for you free of charge. If you experience any difficulty in affixing the label, please contact one of our Owner Care Representatives at 1-800-637-6837.

While you may already be aware of the dangers present with lead/acid wet cell batteries, these labels provide valuable warnings for any subsequent vehicle owners and people/children who may come into contact with the battery after it's useful life has ended and it is removed from your vehicle. Because of this, we emphasize the need for you to have these labels installed on the battery in your vehicle.

If you are not able to have your vehicle repaired without charge and within a reasonable time, you may submit a complaint to the Administrator, National Highway Traffic Safet y Administration, Washington, D.C., 20 590, or call the toll-free Auto Safety Hotline at 1-800-4249393. (Washington, D.C. area residents may call ((202) 366-0123). You may also call ou r Owner Care Department or write to:

Land Rover North America, Inc.
4390 Parliament Place
Lanham, MD 20706
1-800-637-6837
Attn: Owner Care Department

Please note, if the vehicle to which this notice applies has been leased and you are the lessor, you should send a copy of this notice, with the attached label, to the lessee.

We apologize for any inconvenience caused by this recall, but trust that you understand the need to have this condition rectified. Land Rover North America Barbara R. Wheatley Manager, Owner Care

Driveshaft to Differential Connection

A possible defect which relates to motor vehicle safety may exist in some 1995 model year Land Rover vehicles imported by Land Rover North America, Inc.

VEHICLES INVOLVED/CUSTOMER NOTIFICATION
A total of 155 U.S. and Canadian Range Rover Classic, Discovery and Defender 90 vehicles are involved in this recall action.

CUSTOMER NOTIFICATION LETTER
June 2,1995

Dear Land Rover Owner:

This notice is sent to you in accordance with the requirements of the National Traffic and Motor Vehicle Safety Act.

The parts necessary to complete this action are currently available for your Dealer to order from Land Rover North America. The time required to perform this work is approximately 30 minutes.